化工新型材料

化工新型材料 ›› 2021, Vol. 49 ›› Issue (2) : 107-112. DOI: 10.19817/j.cnki.issn 1006-3536.2021.02.025

新材料与新技术

金属螯合制备AZO@TiO₂导电晶须及其性能研究

^1,2

^1,2*

作者信息 +

Preparation and property of electroductive AZO@TiO₂ whisker by metal chelation

Xu Ziao^1,2, Zhu Yanan^1,2, Ge Mingqiao^1,2

Author information +

文章历史 +

Received		Published
2019-11-04		2021-02-20
Issue Date	Revised Date
2021-03-03	2019-11-04

PDF

摘要

AZO@TiO₂导电晶须是一种导电性能好、白度高、价格低廉的导电材料。目前共沉淀法制备该材料难以实现锌铝元素掺杂均匀及近中性反应条件。本研究采用金属螯合法,以AlCl₃和ZnCl₂为原料,以乙酰丙酮为螯合剂,在无水乙醇中溶解得到稳定的金属螯合物前驱体溶液,再通过水解及煅烧在TiO₂表面包覆一层AZO导电膜制备AZO@TiO₂导电晶须。通过单因素试验探究了包覆比、掺杂比、乙酰丙酮的配比和煅烧温度对晶须导电性能的影响,并通过设计四因素三水平正交试验进一步优化工艺参数。借助扫描电子显微镜(SEM)、四探针测试仪、X射线衍射仪(XRD)、能谱分析仪(EDS)、透射电子显微镜(TEM)及热重分析仪(TGA)对所制得的导电晶须进行测试表征,结果表明,以此种方法制得的AZO@TiO₂导电晶须表面电阻率最低达到0.318kΩ·cm。

Abstract

Electroductive AZO@TiO₂ whisker is a conductive material with good conductivity,high whiteness and low price.At present,the preparation of this electroductive whisker is by coprecipitation method.However,the preparation of this material is difficult to achieve uniform doping of zinc and aluminum,and the pH value is difficult to control under near-neutral reaction conditions.The electroductive AZO@TiO₂ whisker was prepared by using metal chelation,aluminum chloride and zinc chloride as raw material and acetylacetone as chelating agent.Metal chloride and acetylacetone was dissolved in ethanol solution,and formed a stable precursor solution.Then a layer of AZO conductive film was coated on the surface of TiO₂ through hydrolysis and calcination.The effects of coating ratio,doping ratio,acetylacetone ratio and annealing temperature on whisker conductivity were investigated by single factor test.Furthermore,four factors and three levels of orthogonal test were designed to further optimize the process parameters.Samples were characterized by X-Ray diffraction (XRD),scanning electronic microscopy (SEM),energy dispersive spectrometer (EDS),transmission electron microscope (TEM) and thermogravimetric analysis (TGA).The results showed that the AZO@TiO₂ had a lowest resistivity of 0.318kΩ·cm.

关键词

导电晶须 / 螯合剂 / 掺杂 / 表面电阻率

Key words

conductive whisker / chelating agent / doping / surface resistivity

引用本文

引用格式 ▾

金属螯合制备AZO@TiO₂导电晶须及其性能研究[J]. 化工新型材料, 2021, 49(2): 107-112 DOI:10.19817/j.cnki.issn 1006-3536.2021.02.025

登录浏览全文

4963

注册一个新账户忘记密码

参考文献

原文顺序 | 出版日期 | 本文引用

[1] 陈红梅,王胜鹏,俞建芳.纺织品及纺织化学品中的高关注度物质(SVHC)[J].现代纺织技术,2012,20(5):48-55.
[2] 高铭.中国纺织标准中的有害物质要求与印染加工[J].印染,2017,43(2):50-55.
[3] 郑艺钦.透明导电氧化物(TCO)材料市场风险和技术挑战分析[J].玻璃,2017,44(7):23-26.
[4] 钱建华,刘娇,许家胜,等.不同粒径TiO₂包覆氧化锡锑后的导电性研究[J].功能材料,2017,48(2):2013-2019.
[5] 葛梦妮,亚辉,周华思,等.Ni包覆Al₂O₃粉体的RCVD法制备及机理研究[J].材料科学与工艺,2017,25(4):78-83.
[6] 王海方,李毅,蒋群杰,等.脉冲激光沉积法制备二氧化钒薄膜的研究进展[J].激光与光电子学进展,2009,46(6):49-53,48.
[7] Darwish A M,Muhammad A,Sarkisov S S,et al.Thermoelectric properties of Al-doped ZnO composite films with polymer nanoparticles prepared by pulsed laser deposition[J].Composites Part B:Engineering,2019,167:406-410.
[8] 王青福,刘新刚,康文彬,等.固相剪切磨盘碾磨法制备四氧化三铁/氮掺杂石墨烯复合材料及其在锂离子电池中的应用[J].材料导报,2018,32(21):3689-3696.
[9] Ma H,Gao Q,Gao C X,et al.Facile Synthesis of Electroconductive AZO@TiO₂ Whiskers and Their Application in Textiles[J].Journal of Nanomaterials,2016,2016:1-7.
[10] Keshtkar J,Vargas G J R,Galaviz P J,et al.Preparation of rod-like Aluminum doped Zinc oxide powders by sol-gel technique using metal chlorides and acetylacetone precursors[J].Journal of Wuhan University of Technology(Materials Science),2018,33(6):1293-1297.
[11] Chen Z W,Li W C,Li R,et al.Fabrication of highly transparent and conductive indium-tin oxide thin films with a high figure of merit via solution processing[J].Langmuir,2013.29(45):13836-13842.
[12] Li J W,Sanjayan S,Alaric T,et al.Single step route to highly transparent,conductive and hazy aluminium doped zinc oxide films[J].RSC Advances,2018.8(74):42300-42307.
[13] 马慧,高强,刘婉婉,等.二次烧结法制备纳米TiO₂晶须的性能研究[J].化工新型材料,2017,45(4):226-227.
[14] Tong H,Deng Z H,Liu Z G,et al.Effects of post-annealing on structural,optical and electrical properties of Al-doped ZnO thin films[J].Applied Surface Science,2011,257(11):4906-4911.
[15] 王志勇,彭超群,王日初,等.聚丙烯酰胺凝胶法制备氧化锌铝(AZO)粉体[J].中国有色金属学报,2013,23(2):480-486.
[16] 王志勇,彭超群,王日初,等.煅烧工艺对氧化锌铝(AZO)粉体光学性能的影响[J].无机材料学报,2013,28(2):171-176.
[17] Chen Z W,Zhan G H,Wu Y P.Sol-gel-hydrothermal synthesis and conductive properties of Al-doped ZnO nanopowders with controllable morphology[J].Journal of Alloys and Compounds,2014,587:692-697.
[18] Lu Z H,Zhou,J X,Wang A J.Synthesis of aluminium-doped ZnO nanocrystals with controllable morphology and enhanced electrical conductivity[J].Journal of Materials Chemistry,2011,21(12):4161-4167.